NJPA National Contracts

 

Model CM1900-2013

30FT COMMAND VEHICLE

 

Specifications

FREIGHTLINER M2-106 2-Door                   

  • GVWR:  35,000 lbs   
  • Engine: Cummins  ISL 300 HP @ 2000 RPM, 2200 GOV RPM, 860 LB/FT @ 1300 RPM
    • NFPA compliant Ember Screen and fire retardant Donaldson air cleaner  
    • 275 AMP alternator with remote battery voltage sensor  
    • (2) GROUP 31, 12-Volt maintenance-free, 2250-CCA batteries   
    • 18.7 CFM Quick-recovery Air Compressor  with internal safety valve       
    • Exhaust Brake with variable geometry turbo and on/off dash switch      
    • RH outboard under-step horizontal aftertreatment system assembly with RH B-Pillar mounted vertical exhaust pipe; bright upper stack; stainless steel device/muffler/tailpipe shield.
    • 6-gallon diesel exhaust fluid tank                             
    • 1100 sq.in radiator          
  • Allison 3000 EVS automatic transmission with PTO port; 6-speed; Push-button electronic shift control, dash mounted.        
  • Front Axle: 12,000 lbs
    • 12,000# dual taperleaf front suspension
    • Shock Absorber               
  • 23,000# R-Series Rear Axle; 5.88 ratio            
    • Driver controlled traction differential and differential lock
    • 16.5X7 Spider cab rear brakes, single anchor; fire and emergency severe service rated                  
    • Haldex Goldseal Longstroke 1-Drive axle spring parking chambers
    • Haldex automatic slack adjusters             
    • 23,000# flat-leaf spring rear suspension with radius rod                
  • WABCO 4S/4M ABS with traction control      
  • 1200 PLUS Air Dryer with integral air governor and heater    
  • DV-2 Auto drain valve with heater on wet tank         
  • Chromed steel bumper with collapsible ends             
  • Front Tow Hooks, frame mounted  
  • Front mud flaps       
  • 50-gallon fuel tank, under left cab   
  • Fuel and water separator    
  • Tires, Front: Goodyear G662 RSA 11R22.5 14-ply radial  (2)   
  • Tires, Rear: Goodyear G288 11R22.5 16-ply radial (4)
  • Wheels: steel, painted white; hub-piloted  
  • 106-in BBC flat-roof aluminum conventional cab with air cab mounts              
  • Exterior cab grab handles    
  • Tilting hood with chromed grille                       
  • Electric horns (2)     
  • Daytime running lights
  • West-Coast bright finish mirrors; heated with left and right remote; 8" bright finish convex mirrors; right-hand down-view mirror                
  • Heater, Defroster, Air Conditioner  
  • Dome Lights, door activated; dual reading lights       
  • 12-volt power supply in dash             
  • Seats: Seats, Inc.  911 Universal Series High-back, air suspension driver and officer with NFPA 1901-2009 compliant seat sensor; 3-point high visibility orange retractor seat belts       
  • Adjustable tilt and telescoping steering column        
  • Low air pressure light and buzzer     
  • Electronic cruise control       
  • Key operated ignition switch and integral start position; 4-position Off/Run/Start/Accessory              
  • Odometer/Trip/Hour/Diagnostic/Voltage Display/Tachometer/Voltage display         
  • Transmission Oil Temperature Gauge            
  • AM/FM/WB Radio with CD player and front auxiliary input;  (2) speakers                                      
  • Paint: one solid color (customer choice)       

Fluid Level Data – Digital Display on VISTA LCD control panel
Vehicle Data Recorder (VDR)

  • Recording:  vehicle speed; acceleration; deceleration; engine speed; engine throttle position; ABS event; seat occupied status; seat belt status; master optical warning switch; park brake; service brake; time; date; engine hours

Warning Plate – Vehicle Specification Data

  • Includes: Vehicle Height; Vehicle Length; Gross Vehicle Weight Rating (GVWR);  Vehicle Occupancy Maximum

Engine compartment light – 5” LED
Cab Step Lights - LED (PR)
Tire Pressure Monitors - 6-Wheel
Tow Eye Plates – black powder-coated under rear body (PR)
COMMAND BODY

  • Modular in design and constructed completely of aluminum
  • Welded, all interlocking extrusion structural design
  • 5052-H32 1/8” thick aircraft structural aluminum panels
  • All seams continuously welded and or interlocked to structural extruded shapes 
  • .125"" bright aluminum rear kick panel extending from bottom of body to floor level
  • Roof covered with bright aluminum treadplate welded around perimeter
  • Floor Structure: 2" x 3" x .125" thick extruded aluminum structural box tubing welded to 4" high x 2.75" wide aluminum I-beam lateral and longitudinal floor structural members
  • Warranty: 10 year structural integrity
  • Body Paint, fire service mirror finish, one-color with all wheels painted to match
  • Body Length:                             228" (19-ft)
  • Body Width:                               98"
  • Overall Height:                          150"" (ground-to-top of AC)
  • Interior Headroom:                 84"

EXTERIOR COMPARTMENTS

  • Left (Street) Side:
    • #1 Forward of rear wheels: 68" wide x 20" high x 20" deep with double vertically hinged doors
    • #2 Aft of rear wheels: 43" wide x 16" high x 20" deep with double vertically hinged doors
  • Right (Curb) Side:
    • #1 Forward of rear wheels: Generator compartment 51" wide x 30" high x 26" deep with double vertically hinged doors.
    • #2 Aft or rear wheels: 43" wide x 16" high x 20" deep with double vertically hinged dooR.
    • #3 Electronic rack exterior access door – 62” high x 21” wide
    • Personnel entrance door with 30” high x 18” wide sliding window
    • Drop-down entrance steps with attachable handrail

Crash Rails, lower body – C-channel aluminum
Stone Guards on each body corner – bright aluminum treadplate
Rear Step Bumper – Steel attached directly to frame rails covered with aggressive bright treadplate
Wheel Chocks (2)
Antenna mounting rails – 58” long on left and right side of roof with weatherproof coaxial port
Data Entry Port with access door on exterior side wall in front of electronics rack
Interior walls, ceiling and floor insulated
Interior walls covered with either sound-deadening carpet or white Kemlite (customer choice)
Lonseal rubberized safety flooring (no seams)
Separate comms, galley and conference rooms with pocket door for each room
Cabinets and Work Centers:

  • Formed aluminum with powder-coated exterior finish (customer color choice)
  • Horizontally hinged overhead doors have mechanical folding hold open mechanism to automatically hold door to an approximate 85-degree opening.
  • Polished acrylic counter tops and tables with rounded bull-nose edges
  • See drawings for cabinet locations and sizes
  • Three-person communications console with cable routing access
  • 37RU Electronic rack with single, hinged, ventilated door
  • 84" x 30" Conference table
  • Chairs, swivel desk (7)

Multiplexed cab and body electrical system

  • Vista LCD color control panel on or in console between seats
    • Diagnostics screen
    • Fluid level screen
    • Warranty notification screen
    • Engine automatic high idle
    • Temperature read-out – external
    • Digital and graphical message display
      • Street side cab doors are not secured
      • Street side body doors are not secured
      • Curb side cab doors are not secured
      • Curb side body doors are not secured
      •  Rear door is not secure
      • Light tower not stowed (if applicable)
      • Awning is not stowed (if applicable)
  • Cab console between seats
    • Black power-coated finish
    • Access pocket storage at back of console with hinged lid - 10" x 12" opening
    • Microphone clip
    • Flexshaft map light and (2) 12VDC power point receptacles
  • LED clearance lights and DOT reflectors
  • LED STOP/TURN/BACKUP Lights – individual with chromed bezels
    • Jake brake stop light activation (projects four multiple impulse flashes on brake lights after application of brakes and then reverts to steady burn brake signals
  • Auxiliary LED turn signals, amber in lower side body crash rails
  • Scene Lights – Upper side body (4) - Whelen 90 LED Opti-Scene
  • Scene Lights – Upper rear body (2) - Whelen 90 LED Opti-Scene
  • Compartment Lights – LED
  • Compartment Open warning light and graphical depiction
  • Ground Lights – LED mounted under body fore and aft of rear wheels and under rear bumper
  • Interior dome lights; (10) Whelen 8” Super-LED with (6) clear diodes with high/low intensity setting and  (3) red diodes for muted lighting

12VDC Power strip, 30-amp - (6) terminals in cab console for radios and other 12vdc equipment
Back-up Alarm
Rearview color backup camera with low-light vision
Antenna coaxial cable routed from roof to cab console
240/120vac Electrical System:

  • Generator, 20kw Kohler diesel load test and certified by UL to  NFPA 1901, Chapter 23.16.2 requirements upon completion of the command vehicle at the factory
  • Power Distribution Panel next to entrance door: Mounted on swing out panel for service access; 23-place 120vac; 3-place 240vac; 100-amp transfer switch from GEN to SHORE; Ceiling Light Switches; Generator Remote and Monitoring Panel; Air Conditioner Thermostats by room; Slide-out Room Actuator Switch (if applicable)
  • 30-amp Shorepower Inlet
  • 100-amp pin and sleeve Shorepower Inlet with 50-ft drop cord with connectors
  • Body Battery System:
    • 90-amp power supply that charges chassis and body batteries
    • Battery Separator/Isolator - body and chassis batteries isolated
    • Interconnect controller to charge batteries from a single or multiple power source
    • Separator logic disconnects two circuits when the voltage falls below battery resting voltage
    • (2) Optima brand Yellow-Top deep-cycle batteries rated at 950 CCA each. 
  • Duplex 120vac, 20-amp interior outlets with GFI (9)
  • 120vac strip outlets with 15-amp plugs spaced every 6” (1)
  • Air Conditioner, roof-mounted (2), plumbed to single air duct system for redundant air flow from all AC units: (5) supply; (4) return
  • Heaters, 120vac, 1500-watt (2)
  • Refrigerator/Freezer - Norcold 2.7 cu.ft.; combination 120vac/12vdc
  • Microwave Oven - 1.2 cu.ft.; 1100-watt

Photos

Model CM1900-2013 Model CM1900-2013